GSW
4.3
Connections for the
automatic start up of the
generator
WARNING
The electrical connections must
only be carried out by specialised
personnel.
NOTE
All the connection operations of the
utilities must be carried out in
compliance with the guidelines
provided on the wiring diagrams.
Connect the cable on which the network or the
remote start-up and stop signal is to be monitored so
as to allow the generator's automatic start-up. Only
the wiring diagram supplied with the generator is to
be referred to for the connection of these signals.
4.4
Commissioning
operations
The operations described in the following
paragraphs must be carried out before proceeding
with the commissioning of the engine.
4.4.1
Visual checks
•
Verify that the generator has not been damaged
during transport.
•
Verify that no parts of the generator have been
disassembled, such as the protections, the air filter,
the tank cap, etc. Otherwise, restore the optimal
conditions.
4.4.2
Checking the engine oil
level
•
Generally, the generator is shipped with oil in the
engine; however, check the level, according to the
instructions provided in the “Inspecting and topping-
up the oil” paragraph.
WARNING
Running the engine without oil or
with oil below the minimum level
will seriously damage it.
4.4.3
First fuel fill-up
•
The generator is shipped without fuel and the
tank must be filled before start-up.
•
Fill the fuel tank up to 60% of its capacity
according to the instructions provided in the
“Refuelling” paragraph with the generator positioned
on a perfectly horizontal surface.
•
It is recommended to also fill the diesel intake
circuit through the special pump. Further information
can be found in the engine manual.
4.4.4
Connecting the battery
cables
•
The battery is shipped by the manufacturer
charged and ready for use.
•
Verify that it has not been damaged during
transport. There must be no signs of impact or acid
leaks. Otherwise, replace the battery.
•
Connect the red cable (
1
) to the positive pole of
the battery (
2
).
80
4.INSTALLATION
Summary of Contents for GSW
Page 2: ...GSW 57 ...
Page 57: ...GSW 112 10 ROUTINE AND EXTRAORDINARY MAINTENANCE LOG ...
