Polaris RANGER CREW 900 2014, Manual

Page: 20 / 447

2
9924880 Rev 2- 1/10/2014 - 2013 / 2014 RANGER XP 900 - 2014 RANGER XP 900 / CREW 900 Service Manual
© Copyright Polaris Sales Inc.
2.3
PERIODIC MAINTENANCE CHART
PERIODIC MAINTENANCE OVERVIEW
Inspection, adjustment and lubrication of important
components are explained in the periodic maintenance
chart.
Inspect, clean, lubricate, adjust and replace parts as
necessary. When inspection reveals the need for
replacement parts, use genuine Pure Polaris parts
available from your Polaris dealer.
NOTE
Service and adjustments are critical. If you’re not
familiar with safe service and adjustment procedures,
have a qualified dealer perform these operations.
Maintenance intervals in the following chart are based
upon average riding conditions and an average vehicle
speed of approximately 10 miles per hour. Vehicles
subjected to severe use must be inspected and serviced
more frequently.
Severe Use Definition
• Frequent immersion in mud, water or sand
• Racing or race-style high RPM use
• Prolonged low speed, heavy load operation
• Extended idle
• Short trip cold weather operation
Pay special attention to the oil level. A rise in oil level
during cold weather can indicate contaminants collecting
in the oil sump or crankcase. Change oil immediately if
the oil level begins to rise. Monitor the oil level, and if it
continues to rise, discontinue use and determine the
cause or see your dealer.
BREAK-IN PERIOD
The break-in period consists of the first 25 hours of
operation, or the time it takes to use 14 gallons (53 liters)
of fuel. Careful treatment of a new engine and drive
components will result in more efficient performance and
longer life for these components.
• Drive vehicle slowly at first while varying the throttle
position. Do not operate at sustained idle.
• Pull only light loads.
• Perform regular checks on fluid levels and other areas
outlined on the daily pre-ride inspection checklist.
• Change both the engine oil and filter after 25 hours or
one month.
• See “Owner’s Manual” for additional break-in
information.
MAINTENANCE CHART KEY
The following symbols denote potential items to be
aware of during maintenance:
■ = CAUTION: Due to the nature of these
adjustments, it is recommended this service be
performed by an authorized Polaris dealer.
▶
= SEVERE USE ITEM: See information provided
above.
E = Emission Control System Service (California).
NOTE
Inspection may reveal the need for replacement parts.
Always use genuine Polaris parts.
WARNING
Improperly performing the procedures marked ■ could
result in component failure and lead to serious injury or
death. Have an authorized Polaris dealer perform these
services.
MAINTENANCE