Piper Cherokee LANCE, Service Manual

Page: 767 / 854

PIPER CHEROKEE SIX / LANCE SERVICE MANUAL
03/27/08 III - INSPECTION
4D9
TABLE III-II. INSPECTION REPORT - PA-32R-300 (cont.)
Inspection
NATURE OF INSPECTION Interval (Hrs)
50 100
B. ENGINE GROUP (CONT.)
37. Inspect engine baffles for condition and security .................................................. O
38. Inspect rubber engine shock mounts for deterioration. (Replace as required.)...... O
39. Inspect firewall seals .............................................................................................. O
40. Lubricate alternator idler pulley (if installed); remove front grease seal
and add grease. (Refer to Lubrication Chart, Section II.) ...................................... O
41. Inspect condition of alternator and starter ............................................................. O
42. Inspect security of alternator and mounting........................................................... O
43. Inspect engine-mounted accessories for condition and security............................ O
44. Inspect condition and tension of alternator drive belt.
(See Checking Alternator Belt Tension, Section X or Adjustment of
Drive Belt Tension, Section XIII if air conditioning is installed.) .........................
O
45. If installed, inspect condition of A/C compressor belt and tension.
(See Adjustment of Drive Belt Tension, Section XIII.) ......................................... O
46. If installed, check A/C compressor oil level. (See Note 8.) ................................... O
47. If installed, inspect A/C compressor clutch security and wiring. (See Note 9.) .... O
48. If installed, inspect A/C compressor mounting for cracks, corrosion,
and security ............................................................................................................ O
49. Check fluid in brake reservoir. Fill as required...................................................... O O
50. Inspect and lubricate all engine controls.
(Refer to Lubrication Chart, Section II.)................................................................ O
51. Install engine cowling ............................................................................................ O O
C. CABIN AND COCKPIT GROUP
1. Inspect cockpit and cabin doors, latches, hinges, and windows, and
aft baggage compartment door, latch, and hinge for damage, operation,
and security ............................................................................................................
O
2. Inspect windows for scratches, crazing, and condition.......................................... O
3. Check window and door seals for deterioration, cracks, and voids ....................... O
4. Inspect upholstery for tears .................................................................................... O
5. Inspect seats and attaching brackets and hardware for condition, security,
and operation. ........................................................................................................
O
6. Inspect seat belts and shoulder harnesses per Section XIII, Restraint System ...... O
7. Inspect trim control operation ................................................................................ O
8. Inspect rudder pedals ............................................................................................. O
9. Inspect parking brake valve and brake handle for operation and cylinder leaks ... O
10. Inspect control wheels, column, pulleys, cables, turnbuckles, and fittings.
(See Note 10.) ........................................................................................................ O
11. Perform Flap Lever to Control Cable Attachment Bolt Inspection.
(See Special Inspections, Procedures, and Note 10.)............................................. O
12. Inspect landing, navigation, strobe, cabin, and instrument lights
for operation, condition, and security .................................................................... O O
13. Inspect instruments, avionics, lines, and attachments............................................ O