Teardrop Campers • nucamprv.com
38
nucamprv.com • Teardrop Campers
39
PROPANE GAS SYSTEM
LP SAFETY
Propane gas, also known as LP or liquefied petroleum, is a naturally
odorless, highly flammable fuel stored in gas cylinders (commonly called
LP tanks) used by appliances such as the stovetop, refrigerator, and Alde
System. A strong odor, almost like sulfur or rotten eggs, is added to the
gas so hazardous leaks can be smelled.
Important Safety Information:
•
ALWAYS close shutoff valves on LP tanks when the propane
system is not in use.
Hand tighten only to avoid damaging interior
seals on the valve.
• DO NOT use open flame to check for leaks. Use the dish soap and
water solution. Spray onto fittings and joints. Bubbles will develop
at the leak point.
• DO NOT restrict access to the LP tank. Always keep the valve
accessible for emergency shutoff.
• DO NOT use any LP tank other than the one supplied with your
trailer unless provided to you by a qualified dealer or
service technician.
• DO NOT block installed vents in your propane compartment. The
compartment must be ventilated for proper air flow.
• DO NOT cross thread, jam or try to force the fitting onto the
hose connector.
• DO NOT pack or store extra LP tanks inside the camper, whether
full or empty. The valves have safety devices that can release gas
into the atmosphere when under high pressure. Always ventilate
your camper when using propane appliances to avoid carbon
monoxide and asphyxiation danger.
• Check the LP gas system for leaks or malfunctioning parts before
each trip to avoid mishaps.
• Always fasten LP tanks securely and properly in the bracket
intended for them.
• When using the propane gas system for the first time, and after the
first 5,000 miles of use, employ a qualified technician to check the
piping for leaks. The piping system is tested and checked at the
factory, but travel vibrations can loosen joints.
• Read and understand operating manuals of all propane powered
appliances before you start using your propane gas system.
• A propane gas alarm is equipped in your camper. See the General
Safety Section of this manual to understand how that works.
IF YOU SMELL PROPANE:
1. Extinguish any open flames, pilot
lights and all smoking materials.
2. Do not touch electrical switches.
3. Shut off the propane supply at
the container valve(s) or propane
supply connection.
4. Open doors and other ventilating
openings.
5. Leave the area until odor clears.
6. Have the propane system checked
and leakage source corrected
before using again.
Ignition of flammable vapors could lead
to a fire or explosion and result in death
or serious injury.
DANGER
The propane piping system is for use with
propane only. Do not connect natural gas
to this system. Securely cap inlet when
not connected for use. After turning on
propane, except after normal cylinder
replacement, test propane piping and
connections to appliances for leakage
with soapy water or bubble solution. Do
not use products that contain ammonia
or chlorine to test for leaks. May lead to
a fire or explosion, which could result in
death or serious injury.
WARNING
FILLING LP TANK(S)
Important information for filling LP tanks:
• Propane appliances will not light when there is an improper mixture
of gas and air. Brand new LP tanks often have air and moisture
trapped inside before first time use. Have a qualified service
technician purge your new LP tanks before filling them for the
first time.
• Only approved DOT propane gas cylinders may be used for
the camper.
• Fill the LP tank at authorized propane fueling facilities only.
• It is illegal to fill an LP tank inside the compartment or inside your
camper. Remove the LP tank from the camper to fill them.
• Never overfill the LP tanks beyond the safe level.
• Always extinguish all open flames and shut off appliances before
removing or reinstalling the LP tank.
• When the LP tank is not connected to the piping system, always
attach a dust cap to the connection fitting to keep it clean.
Steps for properly removing, filling and reinstalling the LP tank(s):
1. Close valves securely on the LP tank(s). Hand tighten only. This will
shut off all appliances.
2. Position the changeover lever to the full bottle.
3. Unthread the pigtail hose attached to the empty LP tank and attach
the dust cap.
4. Remove the empty LP tank from the compartment.
5. Fill the LP tank at a qualified propane fueling station.
6. Place the filled LP tank in the compartment and securely fasten it.
7. Remove the dust cap.
8. Carefully thread and hand tighten the pigtail hose connector onto
the tank’s fitting.
9. Open the valve on the LP tank very slowly to prevent a rush of liquid
propane called freeze-up. If you experience freeze up, close the
valve, wait 15 minutes and try again.
10. When you open the valve, you will hear a hissing noise. If the hiss
lasts longer than 2 seconds, close the valve and have your dealer
service the propane system. You may have a leak.
11. If there is no leak, start appliances according to manufacturer’s
instructions included in your owner’s packet.
Do not fill propane container(s) to more
than 80 percent capacity. A properly filled
container contains approximately 80
per cent of its volume as liquid propane.
Overfilling the propane container(s) can
result in uncontrolled propane flow,
which could lead to a fire or explosion
and result in death or serious injury.
WARNING
Follow Steps 8-10 after stabilizing and
leveling your trailer. Ventilate the camper
and make use of the range hood before
using the cooktop.
Get Cookin’
All pilot lights, appliances and their
igniters shall be turned off before
refueling of motor fuel tanks and/or
propane containers. May cause ignition
of flammable vapors, which can lead to
a fire or explosion and result in death or
serious injury.
DANGER
