Kubota M5660SUH, Operator'S Manual

Page: 108 / 117

PERIODIC SERVICE 86
EVERY 1 YEAR
B
Checking DPF Related Pipe
Consult your local KUBOTA Dealer for this service.
B
Checking EGR Pipe
Consult your local KUBOTA Dealer for this service.
EVERY 2 YEARS
B
Replacing Oil Separator Related Rubber
Pipe
Consult your local KUBOTA Dealer for this service.
B
Replacing DPF Related Rubber Pipe
Consult your local KUBOTA Dealer for this service.
B
Replacing EGR Cooler Rubber Pipe
Consult your local KUBOTA Dealer for this service.
B Replacing Boost Sensor Hose
Consult your local KUBOTA Dealer for this service.
EVERY 4 YEARS
B
Replacing Radiator Hose (Water pipes)
Replace the hoses and clamps.
(See "Checking Radiator Hose and Clamp" in "EVERY
500 HOURS" in "PERIODIC SERVICE" section.)
B Replacing Fuel Hose
Consult your local KUBOTA Dealer for this service.
B
Replacing Intake Air Line
Consult your local KUBOTA Dealer for this service.
B Replacing Power Steering Hose
Consult your local KUBOTA Dealer for this service.
SERVICE AS REQUIRED
B
Bleeding Fuel System
Air must be removed:
1. When the fuel filter or lines are removed.
2. When water is drained from water separator.
3. When tank is completely empty.
4. After the tractor has not been used for a long period of
time.
C Bleeding procedure is as follows:
1. Fill the fuel tank with fuel, and open the fuel cock.
2. Loosen the air vent plug on the fuel filter 2 turns or so.
3. Turn on the key switch and wait for about 1 minute.
Then tighten up the air vent plug.
4. Set the hand throttle lever at the minimum speed
position and turn the key to "START" position.
If the engine doesn't start, try it several times at 30
second intervals.
A Do not hold key switch at engine start position for more
than 10 seconds continuously. If more engine cranking
is needed, try again after 30 seconds.
5. Accelerate the engine to remove the small portion of
air left in the fuel system.
6. If air still remains and the engine stops, repeat the
above steps.
(1) Fuel cock (A) "CLOSE"
(B) "OPEN"
(1) Air vent plug