Kubota L3240, Operator'S Manual

Page: 74 / 157

OPERATING THE TRACTOR 52
CHECK DURING DRIVING
B
IntelliPanel(TM) Message
If any of the following messages appears during
operation, immediately stop the machine and follow the
message's instructions. If the cause of trouble has not
been pinpointed, consult your local KUBOTA Dealer.
C
Engine over heat
If the engine gets overheated, the lamp on the meter
panel lights up and the following messages appear
alternately.
1. Stop operation and set the engine to the idling speed.
2. When the coolant temperature has dropped, the
following messages appear instead.
3. Stop the engine, wait for 30 minutes until the machine
cools down, and check the following points.
(1) Check the reserve tank and radiator for cooling
water shortage or leak.
(2) Check the insect screening and radiator for chaff
and dust deposits.
(3) Check the fan belt for slack.
A If steam gushes out of the reserve tank's overflow
pipe, take the measure discussed above.
C
SERVICE INSPECT
Every 50 operating hours, the "SERVICE INSPECT"
message appears on the meter panel.
1. Finish the job in hand, and do the routine inspection
referring to the hours being displayed.
(See "SERVICE INTERVALS" in "MAINTENANCE"
section.)
2. Reset the "SERVICE INSPECT" message as follows.
Keep pushing both display mode button and travel
speed button for two seconds or more while HOUR
METER MODE.
B
Immediately Stop the Engine if:
A
The engine suddenly slows down or accelerates,
A
Unusual noises are suddenly heard,
A
Exhaust fumes suddenly become very dark,
B
Easy Checker(TM)
If the indicators in the Easy Checker(TM) come on during
operation, immediately stop the engine, and find the
cause as shown below.
Never operate the tractor while Easy Checker(TM) lamp is
on.
A
For checking and servicing of your tractor, consult
your local KUBOTA Dealer for instructions.
(1) "SERVICE INSPECT"
Engine oil pressure
If the oil pressure in the engine goes below the
prescribed level, the indicator in the Easy
Checker(TM) will come on.
If this should happen during operation, and it does
not go off when the engine is accelerated to more
than 1000 rpm, check level of engine oil.
(See "Checking Engine Oil Level" in "DAILY
CHECK" in "PERIODIC SERVICE" section.)
Electrical charge
If the alternator is not charging the battery, the
indicator in the Easy Checker(TM) will come on.
If this should happen during operation, check the
electrical charging system or consult your local
KUBOTA Dealer.
If the HST or GST Transmission malfunctions, the
indicator in the Easy Checker(TM) will blink. If this
should happen during operation, carefully move the
tractor to a safe place, contact your local KUBOTA
Dealer for repairs.