KTM 2012 350 EXC-F SIX DAYS, Owner'S Manual

Page: 35 / 117

SERVICE SCHEDULE
33
8.1
Service schedule
S1N S15A S30A
Read out the fault memory using the KTM diagnostics tool.
x
• • •
Check that the electrical equipment is functioning properly. • • •
Check and charge the battery.
x
• •
Change the engine oil and oil filter, clean the oil screen.
x
( p. 90) • • •
Check the front brake linings. ( p. 67) • •
Check the rear brake linings. ( p. 71) • •
Check the brake discs. ( p. 66) • •
Check the brake lines for damage and leakage. • •
Check the rear brake fluid level. ( p. 70) • •
Check the free travel of the foot brake lever. ( p. 69) • •
Check the frame and swingarm.
x
• •
Check the swingarm bearing. x
•
Check the heim joints at the top and bottom of the shock absorber. x
• •
Check the tire condition. ( p. 76) • • •
Check the tire air pressure. ( p. 77) • • •
Check the wheel bearing for play.
x
• •
Check the wheel hubs.
x
• •
Check the rim run-out.
x
• • •
Check the spoke tension. ( p. 77) • • •
Check the chain, rear sprocket, engine sprocket and chain guide. ( p. 59) • •
Check the chain tension. ( p. 58) • • •
Grease all moving parts (e.g.,side stand, hand lever, chain, ...) and check for smooth operation.
x
• •
Check the fluid level of the hydraulic clutch. ( p. 63) • •
Check the front brake fluid level. ( p. 66) • •
Check the free travel of the hand brake lever. ( p. 65) • •
Check the steering head bearing play. ( p. 49) • • •
Check the valve clearance.
x
• •
Check the clutch. x
•
Change the shaft seal rings of the water pump. x
•
Check the fuel pressure.
x
• •
Check all hoses (e. g., fuel, cooling, bleeding, drainage) and sleeves for cracking, leaks, and incorrect
routing.
x
• • •
Check the antifreeze and coolant level. ( p. 85) • • •
Check the cables for damage and routing without sharp bends.
x
• •
Check that the cables are undamaged, routed without sharp bends and set correctly. • • •
Clean the air filter and air filter box.
x
• •
Change the glass fiber yarn filling of the main silencer.
x
( p. 54) •
Check the screws and nuts for tightness.
x
• • •
Check the headlight setting. ( p. 83) • • •
Check idle.
x
• • •
Check that the radiator fan is functioning properly.
x
(EXC-F SIX DAYS) • • •
Final check: Check the vehicle for roadworthiness and take a test ride. • • •
Read out the fault memory using the KTM diagnostics tool after a test ride. x
• • •
Make the service entry in KTM DEALER.NET and in the service record.
x
• • •
S1N:
Once after 1 operating hour
S15A: Every 15 operating hours
S30A: Every 30 operating hours/after every race