KTM 2008 450 XC ATV, Repair Manual

Page: 55 / 223

07/FUEL TANK, SEAT, TRIM
53
11.4
Installing the radiator spoiler
Info
The operations are the same on the left and right.
100058-10
–
Check parts for damage and wear. Replace damaged or worn parts.
–
Hook the catch

of the radiator spoiler into the holder

of the fuel tank and
position it on the radiator.
100059-10
–
Fit and tighten screws

on the radiator.
Specification
Remaining screws, chassis M6 10 Nm (7.4 lbf ft)
–
Fit and tighten screws

on the fuel tank.
Specification
Screw on fuel tank M6 6 Nm (4.4 lbf ft)
–
Mount the seat ( P. 52)
11.5
Removing the fuel tank
Danger
Fire hazard Fuel can easily catch fire.
–
Never fill up the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
Fuel in the fuel tank expands when warm and can escape if the tank is overfilled. See specifications on filling up with fuel.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse immedi-
ately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed, con-
tact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister according
to regulations and keep it out of the reach of children.
–
Remove the front trim. ( P. 56)
–
Remove the radiator spoiler. ( P. 52)
–
Turn the handle

of the fuel tap to OFF . (Figure 100013-10 P. 55)
600150-10
–
Undo hose clip

.
–
Pull off fuel hose

.
Info
Remaining fuel may run out of the fuel hose.