Kärcher HDS-C 9/15, Original Instructions Manual

Page: 17 / 152

-
1
Please read and comply with
these original instructions prior
to the initial operation of your appliance and
store them for later use or subsequent own-
ers.
Before first start-up it is definitely neces-
sary to read the safety indications Nr.
5.956-309.0!
– All users: Users include trained auxilia-
ry personnel, operators and experts.
– Experts: Experts are individuals, who
are, according to their professional ed-
ucation, able to install the equipment
and to operate the same.
Please do not expose motor oil, fuil, diesel
and gazoline into the environment. Please
protect the ground and dispose of used oil
properly.
Notes about the ingredients (REACH)
You will find current information about the
ingredients at:
www.kaercher.com/REACH
Mishandling or misuse can prove to be haz-
ardous to the operator and other persons
through
– high water pressure,
– hot water,
– hot exhausts (not HDS-C 8/15-E),
– high electrical voltage,
– detergents.
To avoid danger to persons, animals and
property before the first operation of the
system, read:
– the operation instructions
– all safety notices
– according to the national requirements
of each country
– that safety notices included in the
cleaning agents used (normally on top
of the package stated).
– Waste water that is generated must be
diverted into the drainage system by
conforming to the applicable local regu-
lations.
Please remember:
– that you have understood all the in-
structions
– that all users of the plant are informed
about the instructions and have under-
stood them.
All individuals,who are involved, in the in-
stallation, the operation, the maintenance
and service of this equipment, must be
– qualified accordingly,
– they must know and obey the operation
instructions,
– they must know the appropriate regula-
tions, and must obey the same.
In the operation of self service, the owner
must provide cleaned and well exposed no-
tice signs, which have to state
– possible danger,
– Safty device,
– Operating the equipment
For operating HDS-C 7/11 or HDS-C 9/15
in closed rooms
– , exhaust must be lead through appro-
priate pipes or chimneys,
– and there has to be sufficient fresh air
circulation.
몇 WARNING
Risk of burns due to hot parts of the plant
such as pumps and motors. Be careful
while opening the plant; allow parts of the
plant to cool down first.
Only for HDS-C 7/11 and HDS-C 9/15:
Risk of burns due to hot exhaust gases;
hence do not touch the exhaust opening.
Do not touch the chimney opening.
몇
WARNING
Do not use the system in the vicinity of people,
unless they are wearing protective gear.
The jet must not be directed by the user at
him/herself or at other persons to clean
clothing or footwear.
High pressure hoses, fixtures and cou-
plings are important for the safety of the ap-
pliance. Only use high pressure hoses, fix-
tures and couplings recommended by the
manufacturer.
The system must not be used if a connect-
ing line or important parts of the appliance,
e.g. safety devices, high-pressure hoses,
spray guns, are damaged.
– Please follow the national rules and
regulations for fluid spray jets of the re-
spective country.
– All national laws and regulations about
installation of electrical appliances must
also be followed.
– Please follow the national rules and
regulations for accident prevention of
the respective country. Fluid spray jets
must be tested regularly and the results
of these tests must be documented in
writing.
– Only Customer Service engineers
trained by Kärcher may perform set-
tings and carry out maintenance tasks
and repairs.
Only for HDS-C 7/11 and HDS-C 9/15:
– If the plant is operated in rooms, then
there should be adequate measures for
safely diverting the exhaust gases out
of the room (smoke gas pipes without
draught interceptors). Further, there
must also be adequate supply of fresh
air.
– The local guidelines must be followed
while installing the chimney.
– The heating appliance of the machine is
an ignition plant. All national laws and
regulations about heating systems
must also be followed.

DANGER
Pointer to immediate danger, which leads
to severe injuries or death.
몇
WARNING
Pointer to a possibly dangerous situation,
which can lead to severe injuries or death.
몇
CAUTION
Pointer to a possibly dangerous situation,
which can lead to minor injuries.
ATTENTION
Pointer to a possibly dangerous situation,
which can lead to property damage.

DANGER
Risk of injury from the high-pressure jet. Do
not point the high-pressure jet to humans or
animals. Risk of injury from electric shock.
Do not point the high pressure jet towards
electrical devices, cables and the system.
Contents
About this operating instructions
manual. . . . . . . . . . . . . . . . . . . EN 1
Environmental protection. . . . . EN 1
Safety instructions . . . . . . . . . . EN 1
Operations . . . . . . . . . . . . . . . . EN 2
Settings . . . . . . . . . . . . . . . . . . EN 2
Filling in detergents . . . . . . . . . EN 3
Frost protection . . . . . . . . . . . . EN 3
Shutdown. . . . . . . . . . . . . . . . . EN 4
Function. . . . . . . . . . . . . . . . . . EN 5
Specifications . . . . . . . . . . . . . EN 6
Maintenance and care . . . . . . . EN 7
Troubleshooting. . . . . . . . . . . . EN 10
Accessories . . . . . . . . . . . . . . . EN 11
Warranty . . . . . . . . . . . . . . . . . EN 11
Transport . . . . . . . . . . . . . . . . . EN 12
Storage . . . . . . . . . . . . . . . . . . EN 12
Installing the unit (only for ex-
perts) . . . . . . . . . . . . . . . . . . . . EN 12
EU Declaration of Conformity . EN 13
Log of high pressure testing . . EN 14
About this operating
instructions manual
Target group for these instructions
Environmental protection
The packaging materials are re-
cyclable. Please do not throw
packaging in the domestic waste
but pass it on for recycling.
Old units contain valuable recy-
clable materials. Batteries, oil
and similar substances may not
be released into the environment.
Therefore please dispose of old
units through suitable collection
systems.
Safety instructions
General
Specifications and Guidelines
Hazard levels
Symbols on the plant
Risk of electric shock!
Only electricians or authorised
technicians are permitted to
work on parts of the plant.
17 EN