Jayco MELBOURNE 2023, Owner'S Manual, Page: 131 / 143

125
Section 13: Exterior
Chrome parts
To prevent chrome parts from spotting or corroding, wash with water, dry thoroughly, and
apply a non-abrasive automotive wax. If the chrome is severely damaged or pitted, use a
commercially available chrome polish product.
Do not allow plastic to come into contact with brake fluid, engine oil, grease,
paint thinner, or battery acid. These will damage plastic. Use a soft cloth and
a mild detergent solution to wipe away any such contact.
Frame
Frames receive heavy abuse from road conditions such as sand, pebbles, objects in the high-
way, and/or ice inhibiting chemicals, all of which will cause chipping and a blasting effect on
the painted surface. Frames will show signs of rust much sooner when exposed to salty air.
Periodically rinse off the frame (or as use requires) removing road grime, tar, oil, mud or salt.
Refer to your Chassis Guide for the chassis manufacturer’s maintenance instructions.
Mud Flap
Your motor home is equipped with rear wheel mud flaps and/or a deluxe full-width mud flap,
periodically check and remove dirt or debris buildup from the mud flaps.
Cleaning The Diamond Shield Surface
Your motor home is equipped with a protective Diamond Shield surface located on the front
lower cap area, hood edges, generator door, under the entry door grab handle and door lock.
When cleaning the surface, do not use harsh or abrasive cleaners or detergents. The manu-
facturer of the Diamond Shield surface does not recommend the use of any of the dry wash
types of cleaners as they are intended for non-porous surfaces, and paint protection films are
a porous material. Car wash type soap is recommended.
Bugs should be washed off as soon as possible. One bug cleaner recommended by Diamond
Shield is Bug Magic.
Use EXTREME care if using a pressure washer, as too high of a pressure or misuse of
pressure washer may cut or tear the film. Pressure washer damage
IS NOT covered under
Diamond Shield’s warranty. The application of ANY products over Diamond Shield such as
vinyl bras, banners, etc. will void the Diamond Shield warranty
.
Diamond Shield recommends the use of 303 Aerospace Protectant™ or Protect All www.
protectall.com
especially
before any trips. Both of these products replenish and provide
UV screening protection, repel dust, soiling and staining, and should be applied every time
you clean the front of your motor home. For minor scuffs Diamond Shield recommends the
NOVUS line of products. Diamond Shield recommends Mothers or Maguire’s Liquid wax.
DO NOT USE wax designed for specific colors. It is recommended to wax the Diamond
Shield surface at least 3-4 times per year and prior to putting your motor home into storage.
™
NOTE: The use of a protective covering (bra) is not recommended and will
void the limited lifetime warranty of the diamond shield protective surface.
Table of Contents Maintenance Record