![background image](http://html1.mh-extra.com/html/jayco/conventional-travel-trailer-2003/conventional-travel-trailer-2003_owners-manual_3492212056.webp)
101
100
MAINTENANCE CHECKLIST
Prior to First Trip
o
Check LP gas lines for leaks. Refer to Chapter 4.
o
Test carbon monoxide detector (if applicable)
o
Test LP gas detector. Refer to Chapter 4.
o
Sanitize fresh water system. Refer to Chapter 4.
o
Check wheel nuts at specified intervals to listed torque values. Re-torque as
needed. Refer to the axle manufactuer’s manual or Chapter 3.
o
Open all windows and the door and start the furnace. Leave the windows and
door open and the furnace on until the odor from the initial use of the furnace
is fully dissipated.
First Two-Hundred Miles
o
Check wheel nuts at specified intervals to listed torque values. Re-torque as
needed. Refer to the axle manufactuer’s manual or Chapter 3
o
Have brakes adjusted by a qualified service technician.
Each Trip
o
Test LP gas detector. Refer to Chapter 4.
o
Check battery water level. (If equipped with battery.)
o
Check tire pressure and wear. Make sure the tires are cold when checking the
tire pressure.
o
Check running lights.
o
Inspect safety chains for signs of wear.
o
Test brakes.
o
Flush out water heater tank.
After Every Tire Change
o
Tighten wheel nuts to specified torque values at 10, 25 and 50 miles (16, 40,
and 80 kilometers) to assure that they are correctly “seated” after the tire
change. Refer to the axle manufactuer’s manual or Chapter 3
Daily
o
Recharge battery after each use.
o
Ensure LP gas detector operation light is green in color.
Weekly
o
Test LP gas detector.
o
Check tire pressure and wear. Make sure tires are cold when checking the tire
pressure.
Monthly
o
Clean and lubricate the coupler.
o
Check fire extinguisher pressure. Refer to the fire extinguisher label for
specific instructions.
o
Test the ground fault circuit interrupter (GFCI)
Every Three Months or 3,000 Miles
o
Compare water heater pilot flame with ideal flame. Refer to the water heater
owner’s manual for ideal flame. Have cleaned and adjusted as necessary by a
qualified technician.
Figure 7-9
Fifth-Wheel Travel Trailer
1. Moldings
5. Windows
2. TV Antenna
6. Exterior Attachments
3. Vents
7. Marker & Tail Lights
4. Slideout Trim/Moldings
Summary of Contents for Conventional Travel Trailer 2003
Page 9: ...7 6 CHAPTER 2 OBTAINING SERVICE WARRANTY REGISTRATION SAM PLE SAM PLE ...
Page 61: ...111 110 NOTES SAM PLE ...
Page 62: ...113 112 NOTES NOTES ...
Page 63: ...114 NOTES ...