Iseki SXG19H-UE, Operation Manual

Page: 48 / 96

VIII. MAINTENANCE
47
The engine oil filter is located on the Left-hand
wall of the cylinder block.
(1) Engine oil filter
c. Loosen the f ilter using a f ilter spanner and
remove it.
d. Install a new filter with the O-ring lubricated with
fresh engine oil. Screw in the filter until its pack-
ing comes into contact with the sealing surface of
the engine and then tighten it by a 2/3 turn with
the filter spanner.
e. Pour the drained oil back in referring to ’’16
ENGINE OIL REPLACEMENT."
18. TRANSMISSION OIL REPLACEMENT
Important:
• The transmission oil should be replaced after the
initial 50 hours of operation and then after every
200 hours of operation.
• It is recommended to ask your dealer to replace
the transmission oil, because this operation also
requires replacement of the hydraulic oil filter
and washing or replacement of the suction filter.
But when there is no alternative but to replace the
filter by yourself, observe the following instruc-
tions.
The transmission oil drain is located under the center
of transmission case.
(1)Drain plug
a. Place a tray under the drain plug.
b. Remove the drain plug and let the oil drain out.
c. Reinstall the drain plug and tighten it securely.
d. Pour fresh transmission oil through the oil filler
(Refer to page.38) on top of the transmission
case until the transmission case until the level
reaches the upper limit on the level gauge (dip-
stick).
e. After engine oil replacement, start the engine and
let it idle for a while. Then stop it and wait for a
while until the oil comes down into the oil pan.
Now check the oil level to check to see if it is at
the upper limit or not. When the level is low,
replenish until the level reaches the upper limit.
f. Make sure that there is no oil leaking through the
oil filter, suction filter, rubber hoses, or drain
plug.
19. REPLACEMENT OF HYDRAULIC OIL FIL-
TER
Important:
• The hydraulic oil filter should be replaced after
the initial 50 hours of operation and then after
every 200 hours of operation. It should also
changed every time the transmission oil is
replaced.
• It is recommended to ask your dealer to replace
the hydraulic oil fiter. But when there is no alter-
Transmission
oil capacity
Type H-U 8 liters (1.76 imp-gal.)