![Ingersoll-Rand Thermo King CRR DF MPC2000 Maintenance Manual Download Page 122](http://html.mh-extra.com/html/ingersoll-rand/thermo-king-crr-df-mpc2000/thermo-king-crr-df-mpc2000_maintenance-manual_2060249122.webp)
Refrigeration Maintenance and Service Operations
121
Heat Saves Time
A useful and practical time saver is the application of heat to the system. Increasing the temperature of the
compressor oil and refrigerant will speed up the vaporization of any water present in the system.
Heat lamps, electric heaters, or fans can be applied to the compressor crankcase and other parts of the
system to increase the temperature of the refrigerant and compressor oil.
R-134a Refrigeration System Charging
Charging R-134a System with Liquid Refrigerant by Weight (from an
Evacuated Condition)
NOTE: When both the R-134a and R-23 systems require charging, charge the R-23 system first.
1. Close valve V4.
2. Open the Gas Ballast valve (located on top of the pump housing behind the handle).
3. Stop the vacuum pump.
4. The discharge valve remains mid-seated.
5. Connect the refrigerant tank with gauge manifold to the evacuation station (see “Evacuation Station
and Unit Hookup” in this chapter).
1.
Close the vacuum valve and watch the movement of vacuum gauge needle. If
needle shows a pressure rise but finally levels off to a constant pressure, the
system still contains too much moisture. Dehydration and additional evacuation
time are required.
2.
Time
3.
Pressure (Vacuum)
4.
Atmospheric Pressure
Figure 40: Pressure Rise Levels Off After Evacuation Indicates Moisture in System
WARNING: Never use a torch or other concentrated heat source to heat the compressor or
other refrigeration system component.
Summary of Contents for Thermo King CRR DF MPC2000
