Hornbach 6773389, Installation And User Manual

Page: 195 / 218

ENGLISH | 195
WARNING
Manual release test
• Close garage door, then pull down the red
emergency release handle. The trolley will
disconnect.
• Test door for balance by releasing it at
halfway. If balanced, it should stay in
place, supported entirely by its springs.
If the door falls down, seek professional
garage door service.
a
WARNING
Safety reversal system test
• With the door fully open, place a board
with a thickness of 5 cm centered in the
way of the door.
• Press remote control push button. When
closing, the door MUST reverse when mak-
ing contact with the board.
• Otherwise do not use the garage door
opener any more; instead seek profession-
al assistance for repair.
IMPORTANT SAFETY INSTRUCTIONS
WARNING NOTICE - FOR THE SAFETY OF
PERSONS, IT IS IMPORTANT TO FOLLOW
THESE INSTRUCTIONS
THESE INSTRUCTIONS ARE TO BE KEPT.
Important operation instructions
∙
Read and follow all warnings and instruc-
tions.
∙
Always keep remote controls out of the
reach of children. Children shall not play
with the appliance. Cleaning and user
maintenance shall not be made by children
without supervision.
∙
This appliance can be used by children
aged from 8 years and above and persons
with reduced physical, sensory or men-
tal capabilities or lack of experience and
knowledge if they have been given super-
vision or instruction concerning use of the
appliance in a safe way and understand
the hazards involved.
∙
Only activate the garage door when you
clearly see that there are no obstructions
to door travel.
∙
Always keep the garage door in sight until
completely closed. No one should cross
the path of the moving door.
∙
No one should go under a stopped, par-
tially opened door.
∙
Watch the moving door and keep people
away until the door is completely opened
or closed.
∙
Due to remote control the door may move
unexpectedly. No one should cross the
path of a moving door.
∙
If possible, use emergency release handle
only when garage door is closed. Other-
wise make sure, that the garage doorway
is clear of persons and obstructions. Weak
or broken springs or an unbalanced door
could result in an open door falling rapidly
and unexpectedly.
∙
Never use emergency release handle to
pull the garage door open or closed. If rope
knot becomes untied, you could fall.
∙
Frequently examine the installation, in par-
ticular check cables, springs and mount-
ings for signs of wear, damage or imbal-
ance. Do not use if repair or adjustment is
needed since a fault in the installation or
an incorrectly balanced door may cause
injury.
∙
Safety reversal system must be tested
monthly and after any adjustments. The
garage door must reverse on contact with
objects 5 cm above floor level.
∙
Balance of garage door must be tested
monthly. An improperly balanced door
may not reverse when required and could
result in severe injury or death.
∙
All repairs to cables, spring assemblies
and other hardware must be made by a
trained door systems technician.
∙
Each steel wire rope shall have a safety
factor not smaller than 6 (minimum break-
ing strength/static load of one rope).
∙
Rope drums shall have a pitch circle diam-
eter (PCD) at least equal to 20 times the
rope diameter.
∙
Always disconnect electric power to ga-
rage door opener before making any re-
pairs or removing covers.
∙
If necessary, call for authorized service.
∙
Ensure that all safety and danger labels
stay fully legible.
∙
Permanently fix the labels warning against
entrapment in a prominent place or near
any fixed controls.
∙
The drive must not be used with a door
incorporating a wicket door.
∙
The drive is not to be used with doors hav-
ing openings exceeding 50 mm in diam-
eter or having edges or protruding parts a
person could grip or stand on.