C450/ C625
- User Guide (753101)
Rev: 14 MAR 2017
Page: 16
Charging the lift
When the batteries are low and require charging
the light will turn ORANGE on the lift control
panel and an audible alarm will beep every 10 sec-
onds. Complete the transfer that is in progress and
then move lift to the end of the track where the
charger is located.
When the batteries are fully discharged the light
will change to RED on the lift control panel and
the audible alarm will beep every 10 seconds. The
display screen will also FLASH “Low Batt!”.
Note: When the battery is discharged the UP
function will be disabled. If the up button is
pressed the display will show Low Batt! on the fist
line and UP:INHIBITED! on the second line. The
DOWN, EMERGENCY DOWN and X-Y
TRAVERSING will continue to operate.
Figure 8A - Underside of lift showing RED dis-
charged battery indicator light and audible alarm
beeping every 10 seconds.
Display Screen
The charger contacts with two metal charging strips that run along the inside of the track.
Whenever the lift is over a section of track with charging strips it will automatically start to charge
the lift if its battery is low.
The batteries should be charged on a regular basis. It is recommended that the lift be left on charge
when not in operation, and at the end of each day. This will maximize the life cycle of the batteries
The lift may remain connected to the charger indefinitely since the charger has a built-in regulator,
eliminating the danger of overcharging.
As a general rule it is recommended that the carry bar be raised to a height so that it will not
interfere with anything or anyone while the unit is not in use.
When the lift is on the charger the light on the lift will always be ORANGE. After one hour, the lift
may be used, however, overnight charging is recommended. The light will change to GREEN when
the lift is removed from the charger. This indicates that the lift is charged between 25%-100%.
Caution:
Unit can be isolated electrically from “Mains” by unplugging the charger.
Caution:
Do not position the lift in a position where it is difficult to disconnect the charger in an event
of an emergency.
Caution:
Power supply is considered as a part of C-625/C-450 system Use only the charger that was
supplied with the lift. Use of any other charger will void all warranties and may cause damage to the lift.
Note: The lift can be charged with the lift in ON or OFF position.
