Genie S-60, Service Manual

Page: 6 / 12

Part No. 65196 Genie S-60 & Genie S-65
Third Edition • First Printing
TABLE OF CONTENTS
ix
Section Five Troubleshooting Flow Charts
Introduction ............................................................................................................... 5 - 1
Fault Code Chart ...................................................................................................... 5 - 3
1 Engine Will Not Crank Over ............................................................................ 5 - 8
2 Engine Cranks Over But Will Not Start - Gasoline/LPG Models .................... 5 - 10
2A Engine Runs While Cranking then Dies- Gasoline/LPG Models .................... 5 - 12
3 Engine Cranks Over But Will Not Start - Diesel Models ................................ 5 - 13
4 Engine Will Not Start On LPG, But Will Start On Gasoline
- Gasoline/LPG Models ................................................................................. 5 - 16
5 Engine Will Not Start On Gasoline, But Will Start On LPG
- Gasoline/LPG Models ................................................................................. 5 - 18
6 Engine High Idle Inoperative - Gasoline/LPG Models .................................... 5 - 19
7 Engine Low Idle Inoperative - Gasoline/LPG Models .................................... 5 - 20
8 Engine High Idle Inoperative - Diesel Models ................................................ 5 - 21
9 Engine Low Idle Inoperative - Diesel Models ................................................. 5 - 23
10 All Functions Inoperative, Engine Starts and Runs ....................................... 5 - 24
11 All Lift and Steer Functions Inoperative, Drive Functions Operational ........... 5 - 25
12 Ground Controls Inoperative, Platform Controls Operate Normally ............... 5 - 26
13 Platform Controls Inoperative, Ground Controls Operate Normally ............... 5 - 27
14 Boom Up Function Inoperative ...................................................................... 5 - 28
15 Boom Down Function Inoperative ................................................................. 5 - 31
16 Boom Extend Function Inoperative ............................................................... 5 - 34
17 Boom Retract Function Inoperative ............................................................... 5 - 36
18 Turntable Rotate Left Function Inoperative ................................................... 5 - 38
19 Turntable Rotate Right Function Inoperative ................................................. 5 - 42