freightliner CL112 2015, Maintenance Manual

Page: 175 / 180

CAUTION
If the recirculation air filter is not replaced every
six months, damage to the heater and air condi-
tioner components could occur. The HVAC system
should not be operated without the recirculation
air filter installed.
IMPORTANT: When replacing the air filter, use
only a Freightliner-approved air filter.
1. Park the vehicle on a level surface. Apply the
parking brakes and chock the rear tires.
2. Remove the heater and air conditioner cover and
the upper dash cover. For instructions, see
Sec-
tion 60.08 of the Columbia® Workshop Manual .
3. Remove the retainer that holds the recirculation
air filter in place. See
Fig. 4 .
4. Remove and discard the recirculation air filter.
5. Install a new recirculation air filter in the HVAC
assembly.
6. Install the retainer to hold the recirculation air
filter in place.
7. Install the heater and air conditioner cover and
the upper dash cover. For instructions, see
Sec-
tion 60.08 of the Columbia® Workshop Manual .
Sleeper Air Filter Replacement,
Blend Air
Replace the air filter in the sleeper HVAC unit every
six months, regardless of mileage. The filter should
not be cleaned.
CAUTION
If the sleeper air filter is not replaced every six
months, damage to the heater and air conditioner
components could occur. The HVAC system
should not be operated without the recirculation
air filter installed.
1. Turn off the engine, apply the brakes, and chock
the tires.
2. Access the sleeper HVAC assembly by raising
the mattress and bunk panel to the locked posi-
tion. If there is a baggage compartment, the
sleeper HVAC assembly may be accessed
through the baggage door on the right side of the
vehicle.
3. Slide the air filter out of the sleeper HVAC as-
sembly. See
Fig. 5 .
4. Discard the air filter.
5. Place a new air filter in the sleeper HVAC as-
sembly. The edge of the filter should be flush
with the HVAC assembly.
6. Lower the bunk panel and mattress.
7. Remove the chocks from the tires.
02/26/2002 f831491
1
2
1. Retainer
2. Recirculation Air Filter
Fig. 4, Cab Recirculation Air Filter
02/26/2002 f831492
1
1. Air Filter
Fig. 5, Sleeper HVAC Assembly
Heater and Air Conditioner
83
Columbia Maintenance Manual, September 2015
83/3