Modes and Set Up
NOTE:
Where a third party battery is fitted, and
directly coupled to a third party device, it is
recommended that a deep cycle type battery be
installed such as AGM (Absorbent glass matt) or
GEL technology. Due to the resilience of AGM
technology, these batteries will work in any mode.
The timer duration will be met providing the
system voltage stays above the cut off threshold.
However, if the voltage value is below the set
point within the timer value, isolation will occur
at 60 seconds after the minimum voltage is
reached.
NOTE:
The modes in the following table are a
guide. It is not recommended to go below 12V with
a single standard flooded battery. If an incorrect
battery or mode is selected the timer duration
may never be achieved and extra fuel (engine run
time) be required.
Battery Quantity, Type and Timer Modes
Key Off Time
(Minutes)
Minimum
Voltage (V)
Ford Battery
Mode
30
12.2
Single Standard Flooded, No Third Party Battery
1
60
12.2
Single Standard Flooded, With Third Party Battery
2
45
12.0
Twin Standard Flooded, No Third Party Battery
3
90
12.0
Twin Standard Flooded, With Third Party Battery
4
60
12.0
Single AGM, No Third Party Battery
5
120
12.0
Single AGM, With Third Party Battery
6
90
11.8
Twin AGM, No Third Party Battery
7
180
11.8
Twin AGM, With Third Party Battery
8
60
11.8
Nordic Market Twin AGM Batteries, No Third Party
Battery
9
90
11.8
Nordic Market Twin AGM Batteries, With Third Party
Battery
10
Set Up
1. Locate FPBG Interface Connector, under the
parking brake console, see figure E257003.
2. Find the System Mode Pins 15,14,8,7,6,in the
FPBG Interface Connector, see figure E257003.
3. Refer to the Battery Quantity, Type and Timer
Mode table and configure the required mode.
Cut and isolate pins where shown as OFF in
the Mode Configuration Pin table. For example:
If Mode 8 is required, cut wire and isolate to pin
15,14,8 and 6.
Mode Configuration Pins
Pin 6
Pin 7
Pin 8
Pin 14
Pin 15
Mode
Grey Wire
Green Wire
Blue Wire
Red Wire
Black Wire
OFF
OFF
OFF
OFF
ON
1
OFF
OFF
OFF
ON
OFF
2
OFF
OFF
OFF
ON
ON
3
OFF
OFF
ON
OFF
OFF
4
OFF
OFF
ON
OFF
ON
5
OFF
OFF
ON
ON
OFF
6
OFF
OFF
ON
ON
ON
7
OFF
ON
OFF
OFF
OFF
8
OFF
ON
OFF
OFF
ON
9
OFF
ON
OFF
ON
OFF
10
Date of Publication: 03/2018
FORD
TRANSIT
2016.75
4 El
ec
tric
al
123
EU
