414-03B-19
414-03B-19
High Voltage/Traction Battery — Nickel Metal Hydride
DIAGNOSIS AND TESTING (Continued)
Special Tool(s)
Pinpoint Tests
BCM/TIM Breakout Box (BOB) Overlay 418-F220
Special Tool(s)
Traction Battery High-Voltage Service Cord 418-F218
104-Pin Breakout Box (BOB) 418-049 (014-00950) or
Traction Battery Low-Voltage Service Cord 418-F219
equivalent
Traction Battery High-Voltage Lockout and Diagnostic
BCM/TIM Breakout Box (BOB) Adapter Cable
Tool 418-F207
418-F212
(Continued)
PINPOINT TEST A: DTC B2517 EMERGENCY POWER OFF SYSTEM FAULTED
TEST STEP
ACTION TO TAKE
A1 CHECK FUSE
•
Check 15A fuse 7 in the electric vehicle power distribution box
Yes =
GO to A2.
(EVPDB).
•
Is the fuse OK?
No =
REPLACE the fuse. If fuse
fails again,
CHECK/REPAIR for a short
to ground.
A2 CHECK BATTERY CONTROL MODULE (BCM) EMERGENCY
POWER OFF (EPO) STATUS
•
With key ON, monitor BCM PID EMG PO.
Yes =
GO to A5.
•
Does the EMG PO PID indicate ENABLE?
No =
GO to A3.
A3 CHECK EPO DISABLE SIGNAL TO IAA MODULE
•
Connect 104-Pin Breakout Box (BOB) to IAA module C1945; leave IAA Yes =
REPLACE the IAA module.
module disconnected.
•
With key ON, measure the voltage between BOB pin 91 and ground
No =
GO to A4.
(BOB pin 80).
•
Is the voltage greater than 10 volts?
A4 CHECK EPO DISABLE SIGNAL TO TRACTION BATTERY
SUPPORT TRAY
•
Disconnect BOB and reconnect IAA module C1945.
Yes =
REPAIR circuit 3006 (P/LG
wire) between the IAA
module and in-line C1939M.
•
With key OFF, disconnect traction battery support tray in-line C1939 and No =
REMOVE the traction
connect BOB to traction battery support tray in-line C1939F and in-line
battery and REPAIR circuit
C1939M using Traction Battery Low-Voltage Service Cord.
3006 (P/LG wire) between
•
With key ON, measure the voltage between BOB pin 19 and ground
the contactor box and
(BOB pin 65).
traction battery support tray
•
Is the voltage greater than 10 volts?
in-line C1939F.
A5 CHECK TRACTION INVERTER MODULE (TIM) EMERGENCY
POWER OFF (EPO) STATUS
•
With key ON, monitor TIM PID EMG PO.
Yes =
•
Does the EMG PO PID indicate ENABLE?
No =
GO to A6.
A6 CHECK POWER TO IN-LINE C1948
•
With key OFF, disconnect two-pin in-line C1948 (located behind the
Yes =
RECONNECT in-line
high voltage power distribution box [HVPDB]) and measure the voltage
between the O wire on in-line C1948F and ground.
•
Is the voltage greater than 10 volts?
No =
GO to A7.
A7 CHECK POWER TO INERTIA SWITCH
•
With key OFF, disconnect inertia switch C249 and measure the voltage
Yes =
GO to A8.
between the LB/W wire on inertia switch C249 and ground.
•
Is the voltage greater than 10 volts?
No =
REPAIR the LB/W wire.
A8 CHECK INERTIA SWITCH
(Continued)
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
