EP Equipment EPT20-20RA, Operation Manual

Page: 37 / 39

32
–Lubricate the truck in accordance with
the maintenance schedule (See 5.3.2
Lubrication Schedule P27 ).
– Charge the battery (See 4.3Charging
the battery P19).
– Disconnect the battery, clean it and
apply grease to the terminals.
In addition, follow the battery
manufacturer’s instructions.
– Spay all exposed electrical contacts
with a suitable contact spray.
5.4.
5.4. 5.4.
5.4.2
2 2
2 Restoring
Restoring Restoring
Restoring the
the the
the truck
truck truck
truck to
to to
to operation
operation operation
operation after
after after
after decommissioning
decommissioning decommissioning
decommissioning
– Thoroughly clean the truck.
– Lubricate the truck in accordance with the maintenance schedule (See 5.3.2
Lubrication Schedule P27 ).
– Clean the battery, grease the terminals and connect the battery.
– Charge the battery (See 4.3Charging the battery P19).
– Check transmission oil for condensed water and replace if necessary.
– Check hydraulic oil for condensed water and replace if necessary.
– Start up the truck (see 3.2.2Operate and run the truck P14).
Battery powered trucks:
If there are switching problems in the electrical system, apply contact spray to the
exposed contacts and remove any oxide layers on the contacts of the operating
controls by applying them repeatedly.
Perform several brake tests immediately after re-commissioning the truck.
5.5Safety 5.5Safety 5.5Safety 5.5Safety checks checks checks checks to to to to be be be be performed performed performed performed at at at at regular regular regular regular intervals intervals intervals intervals and and and and following following following following any any any any
unusual
unusual unusual
unusual incidents
incidents incidents
incidents
Carry out a safety check in accordance with national regulations. EP has a special
safety department with trained personnel to carry out such checks. The truck must be
inspected at least annually (refer to national regulations) or after any unusual event by
a qualified inspector. The inspector shall assess the condition of the truck from purely
a safety viewpoint, without regard to operational or economic circumstances. The
inspector shall be sufficiently instructed and experienced to be able to assess the
condition of the truck and the effectiveness of the safety mechanisms based on the
technical regulations and principles governing the inspection of forklift trucks.
Warning
Warning Warning
Warning
！
Charge every months:
– Charge the battery.
Battery powered trucks:
The battery must be charged at
regular intervals to avoid depletion of
the battery through self-discharge.
The sulfatisation would destroy the
battery.