Cub Cadet ZT1 42E, Operator'S Manual

Page: 21 / 64

21
SERVICE AND MAINTENANCE
Post-Operation Tractor Care
After each operation of the tractor, the following procedures
should be implemented to extend the life of your tractor and
ensure safe operating conditions.
DANGER
Failure to follow these recommendations may result
in serious injury to yourself or others and may cause
damage to the tractor.
CLEANING THE UNDERSIDE OF THE DECK
WARNING
To prevent serious injury, do not use water to clean the
tractor, battery or battery charger. Do not use strong
detergents. Household cleaners that contain aromatic
oils such as pine and lemon, and solvents such as
kerosene, can damage plastic.
The underside of tractor deck should be cleaned after each use
as grass clippings, leaves, dirt and other debris will accumulate.
This accumulation of grass clippings, etc., is undesirable as it will
promote rust and corrosion.
1. Remove any buildup of grass, leaves and debris on or around
the deck motors and underside of the tractor (DO NOT USE
WATER). Wipe the tractor clean with a dry cloth.
Important: Do not use a pressure washer or garden hose
to clean your tractor. These may cause damage to electric
components or the electric motor. The use of water will result in
shortened life and reduce serviceability.
CLEANING THE TRACTOR
WARNING
If the tractor has been recently run, metal surfaces will
be hot and can cause burns to the skin. Let the tractor
cool for at least five minutes Exercise caution to avoid
burns.
Your tractor should be cleaned after each use and under certain
conditions, i.e. dry conditions and/or mulching situations,
additional cleaning may be necessary.
One of the best ways to keep your tractor running efficiently and
to reduce fire risk is to regularly remove debris buildup from the
tractor. Follow the recommendations below and contact your
authorized dealer with any questions.
• Allow the tractor to cool in an open area before cleaning.
• Do not use water on any part of the tractor (Figure 30).Doing
so can cause damage to the tractor’s electrical components
and motors. The use of compressed air and/or leaf blower or a
brush, damp sponge or rag will help keep the tractor clean.
• Clean around fuses and wiring harnesses.
• Clean the top of the tractor deck.
Figure 30
• Clean around and near the transmission and axle (Figure 31).
Rear Wheel Not
Shown For Clarity
Figure 31
• Debris can accumulate anywhere on the tractor, especially
on horizontal surfaces. Additional cleaning may be necessary
when mowing in dry conditions or when mulching.
• Excess lubrication can become collection sites for debris.
Immediate repair and cleaning up excess lubrication can help
reduce fire hazards.
• In addition to cleaning the tractor before operating and
storing, do not attempt to mow unusually tall grass (10”
(25.4cm) or higher), dry grass (e.g., pasture) or piles of dry
leaves. Dry grass or leaves may build up on the tractor deck
presenting a potential fire hazard.