Super Shot 60 Propane Melter Part Manual
Chapter 8 Troubleshooting
©2018 by Crafco, Inc. All Rights Reserved
………………...…………………………..……………...Illustrated Parts List 8-9
8.0.3. Checking Spark Control Module
Step
Spark Control Module
1
Remove the white rectangular plug from the spark control module and inspect the end for any
damage to the wires going into the plug or to the pins on the inside of the plug.
2
Replace the wiring harness if damage has occurred.
3
Check the spark control module plug mounting tab for possible damage.
4
Replace the spark control module if damage has occurred.
Note:
the spark control module is not repairable in the field.
5
Remove the hi-voltage wire and inspect the end of the wire for any damage to the wire or
terminal. Replace the wire if damage has occurred.
6
Make sure the connection from the terminal fitting and the spark control module is solid and
not loose, tighten if needed.
8.0.4. Burner Flame Adjustment
Step
Burner Flame Adjustment
1
While the burner is “ON”, remove the burner inspection door.
CAUTION
2
Allow some distance at least a foot or two between you and the opening of the inspection
door heat will be coming out this opening.
3
The flame should be approximately four inches in height, mostly orange in color with blue
tips. The flame should be completely around the burner ring.
4
If the flame is not completely around the ring, cycle the burner a few times to see if the result
is the same. If it is than turn “OFF” the propane source and turn “OFF” the control box toggle
switch.
5
Disconnect the propane hose attached to the propane burner, remove the burner door, and
disconnect the ignition and sensor wires at the ignitor, then remove the ignitor. Support the
burner from underneath the unit and unbolt the four bolts holding the burner in place.
Table 8-8 Checking the Spark Control Module
Table 8-9 Burner Flame Adjustment
Summary of Contents for SUPER SHOT 60
