Club Car Precedent 2014, Maintenance And Service Manual

Page: 503 / 548

BATTERIES: ELECTRIC VEHICLE WITH ERIC
CHARGING Battery Care
30
CAUTION
• Do not overfill the batteries.
NOTE: A battery watering gun or bottle is available at many auto parts dealers.
3. The battery hold-downs should be tight enough so that the batteries do not move while the vehicle is in motion,
but not so tight as to crack or buckle the battery case. For 8-volt batteries, tighten hold-down retaining nuts to
106 in·lb (12 N·m). The terminal connections should be clean and tight, and any worn insulation or frayed wires
should be replaced. Tighten battery terminals to proper torque.
See Connecting the Batteries – Electric
Vehicles on page 1-4. See following WARNING.
WARNING
• If battery wire terminals are damaged or corroded, replace or clean them as necessary. Failure to
do so may cause them to overheat during operation and could result in fire, property damage, or
personal injury.
4. After use, charge the batteries. The batteries should never be left discharged any longer than absolutely
necessary (do not leave discharged overnight).
SELF-DISCHARGE
Contaminants on dirty batteries can provide a path for a small current draw that can slowly discharge batteries, thus
wasting valuable energy. To prevent self-discharge, batteries should always be kept clean.
Hot weather also has an effect on a battery’s self-discharge rate. The higher the temperature, the quicker a set of
batteries will discharge. In hotter climates, batteries should be checked more often. When storing batteries, keep in
a cool place.
See Battery Storage on page 30-13.
ELECTROLYTE LEVEL
CAUTION
• Do not allow battery acid from battery caps or hydrometer to drip onto the front or rear body of the
vehicle. Battery acid will cause permanent damage. Wash immediately.
CAUTION CONTINUED ON NEXT PAGE
2014 Precedent ® Golf Car Maintenance and Service Manual Page 30-9