Chevrolet 10 Series 1968, Service Manual, Page: 24 / 713

LUBRICATION 0-21
F ig . 5 —M aintenance and Lubrication Chart - 1/2 and 3 /4 Ton L.D . and F .C .
Vi AND
3/4
TON L.D. F.C.
No. Lubrication Points
Lubrication
Period
Type of
Lubrication
Quantity Remarks
1
King Pins
6,000 Miles Chassis Lubricant 4 places as required
2 Tie Rod Ends 6,000 Miles
Chassis Lubricant 2 places as required
3 Steering Connecting Rod 6,000 Miles Chassis Lubricant 2 places as required 1 fitting at each end
4 Wheel Bearings 30,000 Miles Whl. Brg. Lubricant 2 places as required
5 Steering Gear 36,000 Miles Chassis Lubricant As required Check - do not drain
6 Clutch Cross-Shaft
6,000 Miles Chassis Lubricant As required
7 Brake and Clutch Pedals 6,000 Miles Chassis Lubricant As required
8
Trans. Control Shift Housing 6,000 Miles Chassis Lubricant As required
9 A ir Cleaner - Oil Wetted
Paper Element
12,000 Miles
Check - If satisfactory
- Reuse element
Recheck every 6,000
miles until replaced
- Oil Bath 12,000 Miles Engine Oil SAE 50
Above Freezing
Engine Oil SAE 20
Below Freezing
As required Check - Clean and refill
10 Distributor - L-6 12,000 Miles
1/2 turn of Cam*
Lubricator
11 Transmission - Synchromesh
- Automatic
6.000 Miles
6.000 Miles Multi-Purpose
Dexron
As required
As required
See Lubrication Section
See Lubrication Section
12 Rear Axle 6,000 Miles
Multi-Purpose
As required See Lubrication Section
13 Oil Filter 6,000 Miles
or 6 Months
14 Battery 6,000 Miles Engine Oil Oil Terminals and
Felt Washers
15 Brake Master Cylinder 6,000 Miles Brake Fluid Delco
Supreme #11 As required Check - Add fluid when
necessary
16 Parking Brake Linkage 6,000 Miles Chassis Lubricant
Lubricate Linkage,
Pulleys and Cables
^Replace at 24,000 M ile Intervals
CHEVROLET TRUCK SERVICE MANUAL