Chevrolet 10 Series 1967, Service Manual, Page: 93 / 605

BODY IB-31
Radiator Cap (B)
Open door in shelf panel on inside job just back of the
windshield center post to get to radiator cap.
Gas Tank
1. F iller cap is located at the rear of the right hand
entrance stepwell behind a small door. Open door
and remove gas cap.
2. To remove gas gauge, disconnect gas line and drop
tank to ground.
Engine Housing (G)
1. Release catch and open engine box lid and lock in
open position with hinged support arm.
2. Release catch on inside of box at the upper right hand
corner.
3. Release catches on outside of box at floor level on
the rear and left side.
4. Grasp top flange of box at rear with left hand and
the lid with right hand. Raise slightly to release all
catches and remove the box.
Windshield Wipers (H)
1. To service right hand windshield wiper motor re­
move inspection plate under shelf panel at right side
of firewall directly above tool box.
2. To service left hand wiper motor, remove sim ilar
panel on left side in back of instrument panel in upper
left corner below shelf panel.
3. Controls are mounted on left side of instrument
panel.
4. To adjust position of windshield wiper arms have
them in park position. Mark this position on glass
with grease pencil.
5. Remove the holding nut and lockwasher from the
end of drive shaft.
6
. Lift off wiper arm and knurled driver. In most
cases the knurled driver remains inside the wiper
arm. Tap on arm lightly to remove the driver and
place it back on wiper drive shaft.
7. Position the arm above or below the mark on wind­
shield as desired, replace lockwasher and tighten
holding nut.
Three-Speed Transmission Gear Shift Control Box
To gain access to the steering column manual shift
mechanism mounted on the lower portion of the steer­
ing column mast jacket, remove the radiator grille and
baffle plate on left side of radiator. Leave fresh air
hose connected to plate and push back out of way.
Neutral Safety Switch—Automatic Transmission
To gain access to this switch located on lower portion
of steering column mast jacket follow same instructions
set forth for checking grease in steering gear or for
gaining access to manual shift mechanism on 3-speed
transmission models.
P-10
Numbers refer to figure 72.
Brake Main Cylinder
Open door in instrument panel just back of windshield
M A IN
C YLIN D ER
ifgjPif
Fig . 73 - P10 Main C ylin d e r and 6 C ylin d e r Radiator Access
CHEVROLET TRUCK SERVICE M ANUAL