Case CX490D, Operator'S Manual

Page: 212 / 370

6 - MAINTENANCE
Engine coolant level
WARNING
Hazardous chemicals!
Coolant can be toxic. Avoid contact with skin, eyes, and clothing. Antidotes:
EXTERNAL - Rinse thoroughly with water. Remove soiled clothing.
INTERNAL - Rinse the mouth with water. DO NOT induce vomiting. Seek immediate medical attention.
EYES - Flush with water. Seek immediate medical attention.
Failure to comply could result in death or serious injury.
W0282A
Check the coolant level in the reserve tank every 10 h or every day
Fluid: CASE AKCELA ACTIFULL™ OT EXTENDED LIFE COOLANT
NOTICE: make sure that the level of the engine coolant is checked after the engine has cooled down.
NOTICE: the refilling of the engine coolant should be done only if the level of coolant in the reserve tank is at the
LOW mark.
NOTICE: If the refilling frequency is higher than 250 h , CASE CONSTRUCTION recommends not to further refill the
system: carefully inspect the cooling circuit for damages, replace any damaged part, and then replace the whole fluid
into the cooling system. Refer to the dedicated procedure described ahead in this Chapter.
1. Park the machine on a flat and level place. Stop the
engine, and remove the starter key.
2. Open the front left-hand door.
3. Check that the level of the reserve tank is between the
FULL (1) mark and the LOW (2) mark.
4. If the coolant level is at the LOW mark, remove the
plug (3) and add coolant until the level is right below
the FULL mark.
5. Install the plug (3) .
SMIL19CEX0592AA
1
6-18