BOMBARDIER rally 200, Operator'S Manual

Page: 102 / 130

V06I0SY
Tires/Wheels
Tire Pressure

WARNING
Tire pressure greatly affects vehi-
cle handling and stability. Under-
pressure may cause tire to deflate
and rotate on wheel. Overpres-
sure may burst the tire. Always
follow
recommended pressure.
Since tires are low-pressure types,
a manual pump should be used.
Check pressure when tires are “cold”
before using the vehicle. Tire pres-
sure changes with temperature and
altitude. Recheck pressure if one of
these conditions has changed.
For your convenience, a pressure
gauge is supplied in tool box.
TIRE PRESSURE
FRONT REAR
RECOM-
MENDED
24 kPa (3.5 PSI)
MINIMUM 21 kPa (3 PSI)
Although the tires are specifically de-
signed for off-road use, a flat may still
occur. Therefore, it is recommended
to carry a tire pump and a repair kit.
Tire/Wheel Condition
Check tire for damage and wear. Re-
place if necessary.
Do not rotate tires. The front and
rear tires have a different size. The
tires are directional and their rotation
must be kept in a specific direction for
proper operation.
Wheel Removal
Loosen nuts then lift vehicle. Place a
support under vehicle. Remove nuts
then remove wheel.
At installation, it is recommended to
apply anti-seize lubricant on threads.
Gently tighten nuts in a criss-cross se-
quence then apply a final torque of
70 N•m (52 lbf•ft).
V06H05Y
1
1. Taper side of nut
CAUTION:
Always use the recom-
mended wheel nuts (P/N 250 100
039). Using a different nut could
cause damages to the rim.
Steering System
Throttle Cable Lubrication
The throttle cable must be lubricated
with silicone cable lubricant (P/N 293
600 041) or an equivalent.
_____________________
101