SP-7XE/F Full-Rise Scissor Lift
24
P/N 5900010 — Rev. B — June 2022
2.
Clean each hole. Use a vacuum to thoroughly clean each hole.
⚠
WARNING
Always wear the appropriate eye protection and protective equipment.
If a Vacuum is not available, use a wire brush,
hand pump, or compressed air.
Do
not
ream the hole. Do
not
make the hole any
wider than the drill bit made it.
3.
Verify the Washer and Nut are in place, then insert the Anchor Bolt into the hole. You want
approximately 1/4 inch to 1/3 inch — 6 to 8 mm — of thread visible above the Nut.
The Expansion Sleeve of the Anchor Bolt may prevent the
Anchor Bolt from passing through the hole in the Base; this is
normal. Use a hammer or mallet to get the Expansion Sleeve
through the Base and down into the hole.
Even using a hammer or mallet, the Anchor Bolt should only go
into the hole part of the way; this is normal. If the Anchor Bolt
goes all the way in with little or no resistance, the hole is too
wide.
Once past the hole in the Base, the Anchor Bolt eventually
stops going down into the hole as the Expansion Sleeve
contacts the sides of the hole; this is normal.
4.
Hammer or mallet the Anchor Bolt the rest of the way down into the hole; stop hammering when
the Washer is snug against the Base.
5.
Wrench each Nut
clockwise
to the recommended installation torque, 85 – 95 pound feet (not
less than 80 or more than 105), using a Torque Wrench.
Important
:
Do
not
use an impact wrench to torque the
Anchor Bolts.
Wrenching the Nut forces the wedge up, pushing out the
Expansion Sleeve and pressing it tightly against the Concrete.
Summary of Contents for SP-7XE
