Beckhoff CX2900-0192, Manual

Page: 10 / 36

Safety
CX2900-0192 10 Version: 1.4
2.3 Safety instructions
Follow the safety instructions for protection against injuries and prevention of damage to equipment or
property.
Mounting
• Never work on live equipment. Always switch off the power supply for the device before installation,
troubleshooting or maintenance. Protect the device against unintentional switching on.
• Avoid polarity reversal of the data and supply cables, as this may cause damage to the equipment.
• Observe the relevant accident prevention regulations for your machine (e.g. the BGV A 3, electrical
systems and equipment).
• Note the temperature limit values for operation. If the battery pack is operated outside these
temperature limits, it may leak electrolyte (acid), heat up or even explode.
• The space where the battery pack is located must have adequate ventilation. Follow the regulations of
VDE 0510 Part 2 / EN 50272-2 or corresponding national regulations for storage, installation and
operation.
The battery pack can release flammable gases, which may cause an explosion if it is located in an
enclosed, unventilated space.
• Do not store the battery pack in an airtight container or bag. The battery pack may release flammable
gases, which may explode if the battery pack is hermetically enclosed.
Contact with electrolyte (acid)
• Should you come in contact with electrolyte (acid), immediately rinse the affected body part with water.
Firefighting
Extinguish the battery pack with dry powder, halon or CO
2
.
• Do not use water, which could result in electrolyte (acid) splashing out.
• Disconnect the power supply.
• During firefighting wear self-contained respiratory protective equipment and protective clothing.
• Provide adequate ventilation after the battery pack has been extinguished.
Product safety label
The following product safety label is located on the right side of the battery pack.
CAUTION:
· Do not charge in a gas tight container.
· Do not short the battery terminals.
· Do not incinerate.
· Flush with water at once if contact
is made with electrolyte (Acid).