Page - 1
SECTION 1 - GENERAL INFORMATION
1.1 Contacting AquaCal AutoPilot, Inc.
If you need to call AquaCal AutoPilot, Inc. for questions, services, or parts, please have your
model and serial numbers available. Also have the name of your installer and date of your
equipment’s installation. Please refer to our website for the latest manual revisions, additional
information, and helpful service advice.
Website
www.autopilot.com
Phone
(727) 823-5642
Fax
(727) 821-7471
Address
AquaCal AutoPilot, Inc.
2737 24th Street North
St. Petersburg, FL 33713, USA
Pool volume
(Gallons / Liters)
Installer:
Installation Date:
Cell Type:
Cell Serial #:
Model Type:
Model Serial #:
SECTION 2 - SAFETY INFORMATION
2.1 Safety Information
l
For personal safety, and to avoid damage to equipment, follow all safety instructions displayed on the
equipment and within this manual. Repair and service of your AutoPilot
®
chlorinator must be performed by
qualified service personnel.
l
Should you suspect your chlorine generator is not performing properly, refer to the Troubleshooting
section in this manual to determine if service is required.
See " Troubleshooting" on page 36.
l
Warranties will be voided if the chlorinator has been improperly installed. Failure to properly operate,
maintain or repair the AutoPilot
®
chlorinator will void the factory warranty.
SAFETY SIGNALS
Throughout this manual safety signals are placed where particular attention is
required.
WARNING - Failure to heed the following may result in permanent injury or
death.
CAUTION - Failure to heed the following may result in equipment damage.
Follow all state provincial and NEC (National Electrical Codes) and applicable CEC (Canadian
Electrical Codes) unless local guidelines supersede. When installing and using your Pool Pilot
®
,
basic safety precautions must always be followed, including the following:
WARNING - Failure to heed the following may result in permanent injury or death.
l
RISK OF ELECTRICAL SHOCK - Disconnect all AC power when installing or servicing this system.
Follow all state, local, and National Electrical Code(s) (provincial and Canadian Electrical Code(s) if
applicable). Use copper conductors only.
l
RISK OF ELECTRICAL SHOCK - The Pool Pilot
®
chlorinator contains no owner-repairable
components. Repairs must not be attempted by untrained and / or unqualified individuals. If service is
deemed necessary, contact installing dealer or AquaCal AutoPilot Customer Support.
Summary of Contents for Pool Pilot Digital Nano
Page 2: ......
Page 6: ......
Page 38: ...Page 32 Figure 20 Figure 21 Figure 22 Figure 23 Figure 24...
Page 55: ......